德国Rexroth力士乐比例阀DBET-5X/200G24K4M

随着使用时间的增长，力士乐齿轮泵会出现泵油不足，甚至不泵油等故障，主要原因是有关部位磨损过大。力士乐齿轮泵的磨损部位主要有主动轴与衬套、被动齿轮中心孔与轴销、泵壳内腔与齿轮、齿轮端面与泵盖等。润滑油泵磨损后其主要技术指标达不到要求时，应将其拆卸分解，查清磨损部位及程度，采取相应办法予以修复。

力士乐齿轮泵

一、主动轴与衬套磨损后的修复

力士乐齿轮泵主动轴与衬套磨损后，其配合间隙增大，必将影响泵油量。遇此，可采用修主动轴或衬套的方法恢复其正常的配合间隙。若主动轴磨损轻微，只需压出旧衬套后换上标准尺寸的衬套，配合间隙便可恢复到允许范围。若主动轴与衬套磨损严重且配合间隙严重超标时，不仅要更换衬套，而且主动轴也应用镀铬或振动堆焊法将其直径加大，然后再磨削到标准尺寸，恢复与衬套的配合要求。

二、润滑油泵壳体的修理壳体裂纹的修理：

壳体裂纹可用铸508镍铜焊条焊补。焊缝须紧密而元气孔，与泵盖结合面平面度误差不大于0．05毫米。

主动轴衬套孔与从动轴孔磨损的修理：主动轴衬套孔磨损后，可用铰削方法消除磨损痕迹，然后配用加大至相应尺寸的衬套。从动轴孔磨损也以铰削法消除磨损痕迹，然后按铰削后孔的实际尺寸配制从动轴

泵壳内腔的修理：泵壳内腔磨损后，一般采取内腔镶套法修复，即将内腔搪大后镶配铸铁或钢衬套。镶套后，将内腔搪到要求的尺寸，并把伸出端面的衬套磨去，使其与泵壳结合面平齐。

阀座的修理：限压阀有球形阀和柱塞式阀两种。球形阀座磨损后，可将一钢球放在阀座上，然后用金属棒轻轻敲击钢球，直到球阀与阀座密合为止。如阀座磨损严重，可先铰削除去磨痕，再用上法使之密合。柱塞式阀座磨损后，可放入少许气门砂进行研磨，直到密合为止。

力士乐齿轮泵

三、泵盖的修理

工作平面的修理：若泵盖工作平面磨损较小，可用手工研磨法消除磨损痕迹，即在平台或厚玻璃板上放少许气门砂，然后将泵盖放在上面进行研磨，直到磨损痕迹消除，工作表面平整为止。当泵盖工作平面磨损深度超过0．1毫米时，应采取先车削后研磨的办法修复。

主动轴衬套孔的修理：泵盖上的主动轴衬套孔磨损的修理与壳体主动轴衬套孔磨损的修理方法相同。

四、齿轮的翻转使用

力士乐齿轮泵齿轮磨损主要是在齿厚部位，而齿轮端面和齿顶的磨损都相对较轻。齿轮在齿厚部位都是单侧磨损，所以可将齿轮翻转180度使用。当齿轮端面磨损时，可将端面磨平，同时研磨润滑油泵壳体结合面，以保证齿轮端面与泵盖的间隙在标准范围内。

德国Rexroth力士乐比例阀

原装，质量保证，部分型号现货

DBET-3X/100G24K4       DBET-3X/200G24K4 

DBET-3X/315G24K4       DBET-3X/315G24K4-152 

DBET-3X/315G24K4V      DBET-3X/315YG24K4V  

DBET-3X/50G24K4        DBET-3X/50YG24K4  

DBET-5X/100G24K4M      DBET-5X/100G24K4M-1  

DBET-5X/100G24K4M-27   DBET-5X/100G24K4V 

DBET-5X/100G24NK4M     DBET-5X/100G24NK4M-1 

DBET-5X/100G24NK4V     DBET-5X/100YG24NK4M-1  

DBET-5X/200G12K4M-1    DBET-5X/200G24K4M 

DBET-5X/200G24K4M-1    DBET-5X/200G24K4V-24 

DBET-5X/200G24K4V-27   DBET-5X/200G24N9K4M 

DBET-5X/200G24N9K4M-1  DBET-5X/200G24NK4M-1 

DBET-5X/200YG24K4M-1   DBET-5X/200YG24N9K4M-1 

DBET-5X/315G12K4M-1    DBET-5X/315G24K4M 

DBET-5X/315G24K4M-1    DBET-5X/315G24K4M-27 

DBET-5X/315G24K4V      DBET-5X/315G24K4V-1 

德国Rexroth力士乐比例阀

原装，质量保证，部分型号现货 

DBET-5X/315G24K4V-23   DBET-5X/315G24N9K4M  

DBET-5X/315G24N9K4M-1  DBET-5X/315G24N9K4V-1 

DBET-5X/315G24NJM      DBET-5X/315G24NK4M  

DBET-5X/315G24NK4M-1   DBET-5X/315G24NK4V 

DBET-5X/315G24NK4V-1   DBET-5X/315YG24K4M-1 

DBET-5X/315YG24K4V-1   DBET-5X/315YG24NK4M-1 

DBET-5X/315YG24NK4V-1  DBET-5X/350G24K4M 

DBET-5X/350G24K4M-1    DBET-5X/350G24K4M-26 

DBET-5X/350G24K4M-27   DBET-5X/350G24K4V 

DBET-5X/350G24N9K4M    DBET-5X/350G24N9K4M-1 

DBET-5X/350G24NK4M     DBET-5X/350G24NK4M-1 

DBET-5X/350YG24K4M-1   DBET-5X/350YG24N9K4M-1 

DBET-5X/350YG24NK4M-1  DBET-5X/400G24K4M-8 

DBET-5X/400G24K4V-8    DBET-5X/400G24N9K4M-8 

DBET-5X/400G24NK4M-8   DBET-5X/400YG24NK4M-14 

DBET-5X/50G24K4M       DBET-5X/50G24K4V  

DBET-5X/50G24K4V-1     DBET-5X/50G24NK4M  

DBET-5X/50G24NK4M-1    DBET-5X/50G24NK4M-16  

DBET-5X/50YG24K4M-1    DBET-5X=315G24K4M=DE 

DBET-6X/200G24K4V      DBETB-1X/180G24K4M 

DBETB-1X/230G24K4M     DBETB-1X/230G24K4M-551 

DBETB-1X/25G24K4M      DBETE-6X/200YG24K31F1V

DBET-6X/200YG24K4V     DBETE-6X/200YG24K31A1V

德国Rexroth力士乐比例阀

原装，质量保证，部分型号现货 

DBETE-6X/315YG24K31A1V   DBETE-6X/315G24K31F1V

DBETE-6X/200G24K31F1V    DBETE-6X/350G24K31A1V

DBETE-6X/315G24K31A1V    DBETE-6X/200G24K31A1V

DBETE-6X/100G24K31A1V    DBETE-6X/50G24K31A1V

DBET-5X/400G24N9K4V-8    DBET-5X/200YG24K4M-1

DBETR-1X/315G24K4V-437   DBETR-1X/350G24K4V-409

DBETR-1X/80G24K4V        DBETE-5X/315G24K31M-1

DBET-5X/315G24K4M-1      DBETE-5X/250G24K31M

DBETE-5X/250G24K31M-1    DBETE-5X/315YG24K31M-1

DBETE-5X/100G24K31M      DBET-5X/315YG24K4M-1

DBETE-5X/315G24NK31M-1   DBET-5X/315G24K4M

DBET-51/V-16             DBETE-5X/315YG24K9M-1

DBETE-5X/50G24K31M       DBETR-1X/180G24K4V-575

DBETB-1X/230G24K4M-551   DBETR-1X/230G24K4M-409

DBETR-1X/25G24K4M        DBETR-1X/180G24K4M

DBETB-1X/180G24K4M       DBETR-1X/315G24K4M

DBETR-1X/230G24K4M-381   DBETR-1X/180G24K4M-381

DBETBX-1X/180G24-16K4M   DBETX-1X/180G24-8NZ4M

DBETBX-1X/180G24-37Z4M   DBETBEX-1X/180G24K31A1V

DBETBEX-1X/315G24K31F1M  DBETBEX-1X/80G24K31F1M

DBETBEX-1X/180G24K31F1M  DBETBEX-1X/315G24K0B5M

DBETBEX-1X/250G24K31A1M  DBETBEX-1X/80G24K31A1M

DBETBEX-1X/180G24K31A1M  DBETBEX-1X/315G24K31A1M

德国Rexroth力士乐比例阀

原装，质量保证，部分型号现货 

DBETX-1X/180G24-25NZ4M-36  DBETX-1X/25G24-25NZ4M-36

DBETX-1X/350G24-25NZ4M     DBETX-1X/50G24-8NZ4M

DBETX-1X/250G24-25NZ4M     DBETX-1X/50G24-25NZ4M

DBETX-1X/315G24-25NZ4M     DBETX-1X/180G24-25NZ4M

DBETX-1X/80G24-25NZ4M      DBETX-1X/250G24-8NZ4M-34

DBETX-1X/250G24-8NZ4M-35   DBETX-1X/180G24-8NZ4M-34

DBETX-1X/250G24-25NZ4M-39  DBETFX-1X/80G24-27NZ4M

DBETFX-1X/180G24-27NZ4M    DBETFX-1X/250G24-27NZ4M

DBETFX-1X/315G24-27NZ4M    DBETX-1X/250G24-8NZ4M

DBETX-1X/80G24-8NZ4M       DBETX-1X/315G24-8NZ4M

DBETBX-1X/80G24-16Z4M      DBETBX-1X/230G24-16Z4M

DBETBX-1X/28G24-37Z4M      DBETBX-1X/25G24-16Z4M

DBETBX-1X/80G24-37Z4M-38   DBETBX-1X/315G24-37Z4M-38

DBETBX-1X/315G24-37Z4M     DBETBX-1X/250G24-37Z4M-38

DBETBX-1X/315G24-16Z4M     DBETBX-1X/180G24-16Z4M-37

DBET-6X/420G24K4V          DBET-5X/350G24K4V-1

DBETE-6X/420YG24K31A1V     DBETE-6X/200G24K31A1M

DBET-5X/150G24K4M-32       DBET-6X/100YG24K4V

DBET-6X/315YG24K4V         DBET-6X/350YG24K4V

DBET-6X/50YG24K4V          DBETE-6X/350YG24K31A1V

DBETE-6X/100YG24K31A1V     DBETE-6X/50YG24K31A1V

DBETE-5X/100YG24K31M-1     DBETE-6X/50G24K31A1V=DE

德国Rexroth力士乐比例阀

原装，质量保证，部分型号现货 

DBETE-6X/350G24K31F1V      DBETE-6X/50G24K31F1V

DBETE-6X/250G24K31A1V      DBETE-5X/100G24K31M-1

DBET-6X/350G24K4V          DBET-6X/315G24K4V

DBET-6X/200G24K4V          DBET-6X/100G24K4V

DBET-6X/50G24K4V           DBET-5X/350YG24N9K4V-1

DBET-3X/50YG24K4           DBETE-5X/200G24K31V

DBET-5X/200G24K4M-27       DBET-5X/200G24K4V-21

DBETE-5X/350YG24K31M-1     DBET-5X/200G24N9K4M-1

DBET-5X/315G24K4M-27       DBET-5X/350G24K4M-27

DBETE-5X/315G24K31V-27     DBETE-5X/350G24K31M-27

DBETE-5X/315G24K31M-27     DBET-5X/200G24K4V-27

DBET-5X/200G24NK4V         DBET-5X=315G24K4M=DE

DBETE-5X=50G24K31M=DE      DBETR-1X=80G24K4M=DE

DBETRE-2X=180G24K31A1M=DE  DBETR-1X=180G24K4M=DE

DBET-3X/315YG24K4V         DBETRE-2X/315G24K31A1M

DBETRE-2X/250G24K31A1M     DBETRE-2X/180G24K31A1M

DBET-5X/400G24NK4M-8       DBET-5X/50G24K4M-1

DBETE-5X/200YG24K31M-1     DBETRE-2X/80G24K31A1M

DBETE-5X/315G24N9K31M-1    DBET-3X/315G24K4V

DBET-3X/50G24K4            DBETE-5X/200G24K31M-1

DBET-5X/400G24N9K4M-8      DBET-5X/100G24K4M-1

DBET-5X/315G24NK4V-1       DBETE-5X/350G24NK31M

DBET-3X/315G24K4           DBET-5X/200YG24N9K4M-1